JagExp

The Jaguar Experience Tech Library

Always observe proper safety precautions when servicing your vehicle!

The Jaguar Experience takes no responsibility for damage or injury as a result of any information contained
on this website, and is not responsible for the content of external websites

   

Show Section:  

Featured Technical Articles

No new articles.

Buying a Used Vehicle

Used Car Buying Checklist
A great checklist when buying any kind of used vehicle, print this out and take it with you if you're considering a purchase.
Used Car Buying Checklist (Printable) (pdf)
A nicely formatted, printable PDF version of the SOL Used Car Buying Guide.
XJ Saloon Buyer's Guide
Excellent Buyer's Guide for Jaguar XJ Series 1, Series 2, Series 3, XJ40 (XJ6 & XJ12) type saloon (sedan) cars.

↑ Back to Top

Frequently Asked Questions

Awakening a Sleeping MG
Checklist and procedure for starting an MG (or other similar classic British cars) that have been in long term storage.
Engine No-Crank Troubleshooting, Series III XJ6
How to diagnose a Jaguar XJ6 that won't start.
LBC Fact and Fiction
60 common LBC (Little British Car) questions answered by Motorhead Garages.
What's a DPO?
If you've ever bought a used car, you already know the answer!

↑ Back to Top

General Care

Car Lifts Compared
Choosing a car lift for your home garage: buyer's guide to four post lifts, two post lifts, in-ground, and single post lift systems reviewed and compared.
Leather Care for Classic Cars
How to keep your leather seats from fading or cracking, repairing old or damaged leather, and proper leather seat care instructions to ensure they always look their best.
Twist Drill Talk
How to get the most from your drill bits in the garage, and how to sharpen, inspect and keep them in top working order.

↑ Back to Top

Service and Repair

Basic Servicing

Automatic Transmission Routine Service, Series III XJ6 XJ12
Inspection, flushing and refilling of the Borg-Warner or GM Turbo-Hydramatic 400 automatic transmission fluid and filter parts for Jaguar XJ6 and XJ12 (Series III & XJ40)
Brake System Routine Service, Series III XJ6 XJ12
Inspection, replacement of front & rear brake fluid, hoses, pads and rotors parts for Jaguar XJ6 and XJ12 (Series III & XJ40)
Engine Cooling System Routine Service, Series III XJ6 XJ12
Inspection and maintenance of engine cooling system radiator, cap, water pump parts for Jaguar XJ6 and XJ12 (Series III & XJ40)
Engine Drive Belt Service, Series III XJ6 XJ12
Inspection and maintenance of drive belts, fan, alternator and accessory belts parts for Jaguar XJ6 and XJ12 (Series III & XJ40)
Jacking and Supporting your Series III XJ6 XJ12
How & where to jack your Jaguar XJ6 and XJ12 (Series III & XJ40) and support it with jack stands for service and maintenance.
No Start Troubleshooting, Series III XJ6 XJ12
If your XJ6 or XJ12 won't start, grab your voltmeter and follow this checklist. Covers checking spark plugs, coil, wires and distributor cap, ballast resistor, amplifier and distributor pick-up, fuel supply, fuel pump and relay, air flow meter, fuel injectors and ECU.
Spark Plug and Ignition System Maintenance, Series III XJ6 XJ12
Changing the spark plugs and inspecting the ignition system and distributor parts on the Jaguar XJ6 and XJ12 (Series III & XJ40)
Wheel Bearing Routine Service, Series III XJ6 XJ12
Greasing the front and rear wheel bearings on your Jaguar XJ6 and XJ12 (Series III & XJ40)
XJ Engine Oil And Filter Routine Service, Series III XJ6 XJ12
Recommendations on changing the oil and oil filter in your Jaguar XJ6 and XJ12 (Series III & XJ40)

Troubleshooting

Troubleshooting Guide for Classic Cars
A step-by-step chart to help diagnose the cause of nearly any problem you might have with your LBC, and the corresponding solution.

Tops and Windows

Tonneau Cover Installation
Getting all the snaps (Lift-the-Dots) aligned on your new tonneau cover.

Suspension and Wheels

Aftermarket Wheels For Your XJ6 and XJ-S
Bolt pattern choices for aftermarket Jaguar wheels and interchangability notes between XJ models.
Mounting Tires the DIY Way
How to change your wheel tires and tubes, and get a nice cardio workout for free.
Rear Differential Routine Service, Series III XJ6 XJ12
Inspection and maintenance, oil refilling procedure on rear suspension differential, LSD identification on the Jaguar XJ6 Series III.

Brakes and Clutch

Bleeding The Hydraulic Clutch System
A simple tip that might solve your clutch bleeding frustration.
Bleeding Your Brakes
How to replace the brake fluid and eliminate air bubbles from your car or truck's hydraulic braking system, known as "bleeding" the brakes.
Quieting Brake Squeal
Some tips on how to cure squeaky brakes.

Cooling and Heating

Auxiliary Electric Engine Cooling Fan Checklist, Series III XJ6
Operation and troubleshooting repair of the electric auxiliary engine cooling fan on the Jaguar XJ6 Series III.
Modern Automotive Coolants
How engine coolant has evolved over the years, and what modern coolant is the best for our classic British cars.

Engine and Tuning

Make a Spark Tester
Diagnosing a weak spark with a few bits and pieces from the junk bin.
Oil Filter Study
A good website showing what oil filters are made of, and good and bad components to look for.
Piston Stop Cam Timing Tool
Making a handy tool to find TDC accurately.
The Gasket Basket
Making your own gaskets: materials, theory and installation.
Today's Oils and Our Classic Cars
Presentation from George Morrison, independent STLE Certified Lubrication Specialist, at a Central Ohio MG Owners Club Tech Session regarding the use of modern oils in classic cars.

Carburetors and Fuel

Fuel Filter and Hoses Routine Service, Series III XJ6 XJ12
Maintenance, inspection and replacement of fuel filter and hoses parts on fuel injected Jaguar XJ6 and XJ12 (Series III & XJ40)
Fuel Pump Circuit Troubleshooting, Series III XJ6
Car won't start? This article explains the operation of the fuel pump circuit and offers an easy-to-follow fault diagnosis procedure for all Jaguar Series III XJ6 cars.
Fuel Tank Switchover Troubleshooting, Series III XJ6
This checklist will describe the operation of the fuel changeover and provide a diagnostic checklist to aid in troubleshooting. This information specifically applies to Series III 6 cylinder cars but may also be applicable to the later Series II models with fuel injection as well as fuel injected 12 cylinder cars.
How To Blow Through an SU
Notes on the use of the HS or HIF series SU carburetors in a forced induction turbo or supercharger blow-through configuration.
SU Fuel Pump Troubleshooting Guide
Troubleshooting guide for all classic cars and trucks that use SU mechanical (points type) fuel pumps.
SU Fuel Pumps 101
Basics on the types and operation of the SU fuel pump.
Troubleshooting Rich Fuel Mixture on EFI Systems, XJ6 Series II and III
Diagnosing rich running on the fuel injected 4.2L engine, covers checking of the coolant temperature sensor, fuel pressure regulator, oxygen sensor, fuel injectors, cold start circuit, fuel changeover system, air flow meter (AFM), and ECU.
Weber Carburetor Factory Settings (pdf)
Stock settings for various Weber carburetors, a good starting place for tuning.

Electrical and Instruments

Battery Storage, Fact or Fiction?
Will leaving your battery sitting on concrete cause it to discharge?
Car Batteries 101
Testing, maintenance, troubleshooting and charging advice for the common automotive 12V lead-acid car battery.
Dash Rocker Switch Repair
Rehabilitation of the "Clear Hooters" type dash rocker switches common to many British cars of the 1970s such as Triumph, MG and Jaguar.
Ground Point Preparation
Removing corrosion from your car's ground points often solves all kinds of electrical gremlins.
Pertronix Installation Secrets
Pertronix Electronic Ignition (Ignitor kit etc) installation tips for vintage points type distributor upgrades, that aren't listed in the manual
Servicing The Lucas Wiper Switch
How to restore the Lucas Wiper, Washer, and Overdrive switch stalk from the early 1970s MGB and other British vehicles of similar vintage.
Smiths Tachometer Servicing
Common faults, part numbers, calibration and negative ground conversion.
Understanding Alternators
Operation and theory of the alternator, explained in simple terms.
Understanding the Ignition System
Operation and theory of the ignition system, explained in simple terms.
XJ Horn Circuit Troubleshooting
Checklist for inspection and repair of the XJ Series III horn, circuits and relays.
XJ Power Window Circuit Troubleshooting
Checklist for inspection and repair of the XJ Series III power window circuits and relays.
XJ6 Headlamp Circuit Troubleshooting
Checklist for fixing faulty XJ6 Series III headlamps.
XJ6 Parking Light and Marker Circuit Troubleshooting
Checklist for fixing faulty XJ6 Series III parking and marker lamps.

Interior and Upholstery

Adjusting the Sunroof and Fixing Leaks, Series III XJ6 XJ12
Adjusting the outer panel fitment for the XJ sunroof, and replacing weather stripping to fix leaks.
DIY Wood Steering Wheel: Part 1 Introduction, Design & Prototype
How to build your own wooden steering wheel: Justification, Budget, Objectives, Donor Wheel, Design, and building a Prototype.
DIY Wood Steering Wheel: Part 2 Choosing Wood, Making Blanks
How to build your own wooden steering wheel: choosing lumber for making the wheel, material list and cost, design and making the blanks for the halves, cutting segments and making splines, gluing the hexagons
DIY Wood Steering Wheel: Part 3 Machining the Halves & Rounding
How to build your own wooden steering wheel: making a router table, marking the wood, cutting the shape of the wheel and center groove, assembling wheel halves and rounding
DIY Wood Steering Wheel: Part 4 Fitting the Wood to the Steel & Finger Grooves
How to build your own wooden steering wheel: fitting the wooden wheel to the steel frame, cutting space for the spokes, making finger grooves with a wood file
DIY Wood Steering Wheel: Part 5 Attaching to the Steel Frame & Finishing
How to build your own wooden steering wheel: fastening the wooden wheel to the frame with epoxy, clamping, finishing hand sanding, mother of pearl inlay, wood stain and varnish
DIY Wood Steering Wheel: Part 6 The Finished Product & Conclusion
How to build your own wooden steering wheel: the finished steering wheel, final thoughts and total time and cost tallies (Final Part)
Low Cost Cockpit Sound and Thermal Insulation
How I made low-cost thermal and sound insulation for my car's interior, and a comparison to Dynamat Extreme.
New Veneer On A Wood Dash
Refinishing the wood dash on a Triumph Spitfire

↑ Back to Top

Body and Paint

Car Bodywork 101: Lesson #1 Prep Work
The first part of the series on automotive bodywork, Prep Work, covers basic preparation before painting such as rough sanding, applying and sanding filler, applying and sanding primer, and fixing high spots.
Car Bodywork 101: Lesson #2 Sanding Jamb Areas
Part 2 in this series on automotive bodywork, Sanding Door and Hood Jamb Areas, covers "jambing", basic sanding technique, supplies like sandpaper, Scotchbrite and blocks, sanding technique, cleaning and paint masking tips.
Car Bodywork 101: Lesson #3 Painting Jamb Areas
Part 3 in this series on automotive bodywork, Painting Door and Hood Jamb Areas, covers Tools for Automotive Painting, Fixing Paint Runs and Overspray, Block Sanding Final Primer, and color hold-out (even color).
Car Bodywork 101: Lesson #4 Final Paint Prep
Part 4 in this series on automotive bodywork covers Final Body Preparation, Masking the Body, Masking Curves and Letters, Masking Cracks and Tight Areas, and Final Air and Solvent Cleaning.
Car Bodywork 101: Lesson #5 Painting
Time for Paint! Part 5 in this series covers Mixing Automotive Paint, Automotive Paint Systems, Painting in Your Garage, and Painting Tips.
Car Bodywork 101: Lesson #6 Undercoating
The final part of this automotive bodywork tutorial series covers undercoating your car and final words on bodywork and painting.
Color Sanding Instructions
Supplies list and method to get an excellent finish after repainting your car.
How to use Body Filler on Repair Panels
How to blend in a new body panel with filler and block sanding for a perfect paint job (Bodywork for Beginners Series)

↑ Back to Top

Restoration

Build a Body Rotator
The ultimate low-buck body restoration aid (mirror)
Media Blasting and Air Compressors Explained
How to choose the right blasting equipment for car restoration; sand, slag, alox, and glass beads; gun and nozzle selection and air compressor buying guide.

↑ Back to Top

Reference

1972 BMC USA Price List
Dealer price list for BMC/British Leyland vehicles and factory options in 1972.
Bolt Torque Specification
Universal torque specs in ft-lbs for SAE Grade steel hex bolts.
British Car Production Figures
Total production data for all British makes and models.
CO% to Air Fuel Ratio (AFR) Table
Handy chart for CO based tuning.
Standard Threads Reference
Table comparing UNC, UNF, USP, BSW (Whitworth), BSP (Pipe) and Metric threads.
Triplex Window Date Code
If your car has the original Triplex windows, you can read the date code and estimate when your car was assembled using this secret decoder key.
US-British Technical Terms
Translations of terms with different meanings on different sides of the Atlantic.
Wrench and Socket Reference
Reference table of US (Imperial), Metric and Whitworth wrench sizes.

↑ Back to Top

Streaming Video

Secrets of the SU Carburetter
Video tutorial on inspection and rebuilding of the SU carburetor(s) fitted to MGBs prior to 1975, Triumph, Jaguar, Mini, Austin, Morris and many other British cars as well as classic Volvo and Saab.

↑ Back to Top

Humour and Miscellaneous

Holiday Prose, LBC Style
A Little British Car themed "Night Before Christmas".

↑ Back to Top




Join The Club

Sign in to ask questions, share photos, and access all website features

Your Cars

1996 Jaguar XJS

Text Size

Larger Smaller
Reset Save